Fuel Filter The fuel filter is quite well hidden, it is behind the nearside rear wheel arch. Jack the car up, remove the wheel and remove the arch liner. On each end of the filter is a connector with an orange clip. To disconnect the pipe you just have to push the...
Smartmods
for all your modding needs, recommended by Evilution
News
451 CDI Intercooler Removal
Should you decide to change the problem EGR cooler on your 54bhp CDI, You'll need to remove the intercooler. Before you do this I would recommend not bothing and just bypass it instead. Do You Wish To Continue? Mad man! Loosen both hose clamps using a 7mm socket....
451 Valve Clearance Specs
Sometimes, information doesn't need to take up loads of pages. Sometimes, the information is really all that needs to be on the page. This is one of those pages. I could use a massive font to take up more room I suppose but I won't. Important These clearance readings...
Roadster Starter Motor Removal
Fully lower the engine using the engine lowering studs. Click here. The starter motor is down the back of the engine behind the inlet manifold. Disconnect the 2 coolant pipes that run over the top of the starter motor. It's hard to see what the hell is going on as...
Secondary Air Injection Pump
It is becoming more and more common for people to report a terrible noise for about 90 seconds on start up. This is due to the secondary air pump. People with no actual clue often call this an EGR pump. This secondary air injection pump can be found on 700cc fortwos...
451 DPF Regeneration
What Is A DPF? It's a diesel particulate filter, it's inside the exhaust. It catches all of the particles of soot from the engine. This improves the quality of the emissions from the exhaust. Do I Have A DPF The smart fortwo 451 diesel manufactured after October 2009...
Roadster Clutch Removal
The clutch doesn't last forever. It wears down causing slipping and poor pull away.
453 Gearbox Fluid Change
The 453 comes with 3 option for the gearbox. The turbo and non turbo petrol model had the option for either manual or auto. The electric drive model only came with a fixed ratio gearbox (not yet covered here). Manual Gearbox Fluid Change Post yourself under the car...
Roadster Coolant Draining/Filling
Draining The best way to drain the system is at its lowest point, in the smart's case they have actually installed a coolant drain plug that can be removed with a 6mm allen key. It is located on the back of the engine. Lay down under the back of the car and you'll see...
451 CDI Fuel Tank Drain
OK, so you put the wrong fuel in your car like a total moron. You know this already. You need to empty the tank so you can fill it with the correct fuel. Fuel Filter The fuel filter is quite well hidden, it is behind the offside rear wheel arch. Jack the car up,...
450 Fuel Tank Drain
Fuel Filter The fuel filter is quite well hidden, it is behind the offside rear wheel arch. Jack the car up, remove the wheel and remove the arch liner. On each end of the filter is a connector with an orange clip. To disconnect the pipe you just have to push the...
Roadster Thermostat Valve Change
What Are The Symptoms Of A Failed Thermostatic Valve? The thermostatic valve starts closed which only allows the the water to circulate around the engine. As the engine temperature increases, the water temperature also increases. This causes the valve to slowly oen,...
450 Starter Motor Fix
This is the starter motor removed from the car. Actually removing it is a terrible job. Annoyingly, it's rarely the starter motor that fails so removing it is usually unnecessary. So, if you go to start the car and you only hear a click from the fuse box, you may have...
Roadster Starter Motor Fix
This is the starter motor removed from the car. Actually removing it is a terrible job. Annoyingly, it's rarely the starter motor that fails so removing it is usually unnecessary. So, if you go to start the car and you only hear a click from the fuse box, you have a...
S-mann Exhaust Fitting
Mid way between MOT's I had the emissions checked on my 2011 fortwo 451 turbo and it looked like it would fail when the MOT came around. It was a 2nd hand Brabus exhaust that I had put on in 2012 so it had lasted OK. I didn't really want to put the standard exhaust...
451 CDI Exhaust Pressure Sensor
What Happens When It Fails? Initially the car goes into a "kind of" safe mode. Normal safe mode severely reduces the power from the engine which normally limits the top speed of the car to about 40mph. When the exhaust pressure sensor fails, you'll get a reduction in...
Roadster AC Pipe Replacement
The Roadster has a nasty habit of snapping the air conditioning pipes.
Throttle Body Orientation
I get this question a few times a year. "I can't close my engine cover" When I first heard it back in 2006, I thought they were just being a mong with no dexterity. Then I received a photo. After that, every photo has been the same. I have no idea how they end up like...
451 CDI Engine Removal
In the history of evilution, I had never had to remove an engine. Just my luck I had to start on the hardest one. Even then, I wouldn't go as far as saying it was hard, just time consuming, awkward and daunting. Including taking photos and notes, I achieved this in...
Roadster Alternator Change
Get The Right Alternator When I initially fitted a replacement alternator to my Roadster it didn't actually work. I thought I had misdiagnosed the fault but actually I had been sold the wrong alternator for my car. On the smart there seems to be 6 different...